TM 5-3895-369-14
Table
4-3. Troubleshooting Symptom index
Engine Fault Index
Description
Fault
Page
Engine fails to crank or cranks slowly with clutch disengaged ............................................
1.
Engine cranks but will not start - no smoke from exhaust ...................................................
2.
Engine hard to start or will not start - smoke from exhaust ................................................
3.
4.
Engine starts but will not keep running .................................................................................
5.
Engine surges (speed changes) ................................................................................................
6
Engine idles rough .....................................................................................................................
7
Engine runs rough or misfires ..................................................................................................
8.
Engine rpm will not reach rated operating speed .................................................................
Engine fails to develop full power ...........................................................................................
9.
Engine exhaust smokes excessively .........................................................................................
10.
11.
Engine operating temperature too high .................................................................................
12.
Engine operating temperature too low ..................................................................................
Engine oil pressure too high ....................................................................................................
13.
14.
Engine oil pressure too low ......................................................................................................
Engine losing oil .........................................................................................................................
15.
16.
Fuel or oil leaking from exhaust manifold .............................................................................
17.
Compression knocks ..................................................................................................................
18.
Excessive fuel consumption ......................................................................................................
Excessive vibration .....................................................................................................................
19.
Unusual engine noise ................................................................................................................
20.
Battery dead and will not hold a charge ..................................................................................
21.
22.
Alternator does not charge batteries ......................................................................................
Additive System Fault lndex
Fault
Description
Page
23.
Additive pump turns but will not pump additive solution ..................................................
Additive pump will not operate (will not turn) .....................................................................
24.
Rotor Tiller Fault Index
Description
Fault
Page
25.
Boom cylinder stutters or will not raise and lower rotor assembly ....................................
Gate cylinder stutters or will not raise and lower tailboard ................................................
26.
Spray bar cylinder stutters or will not open and close spray bar .........................................
27.
Vehicle Fault Index
Description
Fault
Page
Vehicle does not move forward or in reverse correctly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
28.
Steering is difficult . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
29.
4-13
