TM 5-3895-359-14&P
LUBRICATION CHART 1 - GENERAL (Continued)
T
HYDRAULIC OIL RESERVOIR (1) * SEE BELOW
CHECK OIL LEVEL DAILY. DRAIN, FLUSH AND
REFILL SYSTEM EVERY 2000 RUNNING HOURS,
INCLUDING OIL FILTER. CAPACITY: 10t GALS.
APPROX. POUR OIL THRU A 75 MICRON FILTER OR
2000 MESH SCREEN. PERIODICALLY CLEAN FILTER
ELEMENT WITH SOLVENT AND BLOW AIR DRY.
MAINTAIN TANK BREATHER CAP CLEAN.
U
POWER STEERING PUMP
SAME AS (T)
CHECK OIL LEVEL DAILY. SERVICE EVERY 500
RESERVOIR (1)
RUNNING HOURS. DRAIN, FLUSH AND REFILL
RESERVOIR TO LEVEL. CAPACITY: 3 PINTS. POUR
OIL THRU A 75 MICRON FILTER OR 200 MESH
SCREEN.
V
ENGINE COOLING SYSTEM
WATER-FREE OF
CHECK DAILY. FILL AS REQUIRED. CAPACITY:
MINERALS WITH
34 GALS. APPROX. IT IS RECOMMENDED NOT TO USE
RUST INHIBITOR
AN ANTI-FREEZE CONTAINING A LEAK PREVENTA-
ADDED.
TIVE ADDITIVE.
ANTI-FREEZE
WHEN REQUIRED.
W
ENGINE AIR CLEANER
--
CHECK AND EMPTY BOWL DAILY. CLEAN ELEMENT
(DRY TYPE)
PERIODICALLY. CHANGE ELEMENT AS REQUIRED.
X
FUEL TANK (NOT SHOWN)
DIESEL FUEL OIL FILL AS REQUIRED. CAPACITY: 80 GALS.
NO. 2D
ENGINE
--
REFER TO ENGINE MANUAL
TIRES:
FRONT:
STANDARD 30 P.S.I.; OPTIONAL 30 P.S.I.
REAR:
STANDARD 18 P.S.I.; OPTIONAL 16 P.S.I.
* N.L.G.I. NATIONAL LUBRICATING GREASE INSTITUTE.
**
HYDRAULIC OIL PROPERTIES
TYPICAL VISCOSITY SUS VISCOSITY
POUR
OPERATING
FLUID TYPE
INDEX
POINT
F
RANGE(TYPICAL .)
F
0
F
100
F
210
F
ANTI-WEAR HYDRAULIC OIL
7,000
200
50
132
-30
0 - 200
F
TYPE "F"
3,200
212
57.2
208
-40
-15 - 200
F
HYDRAULIC TRANS. OIL
12,000
233
49
100 MIN.
-35
0 - 200
F
PYDRAUL 312
100,000
312
51
77
-10
50-200
F
FIRE RESISTANT FLUID
THE ABOVE LISTING MAY BE PRESENTED TO YOUR OIL COMPANY AS A GUIDELINE FOR SELECTING THEIR
BRAND
OF OIL FALLING IN THE CATEGORY OF THE RECOMMENDED FLUIDS FOR USE WITH SUNDSTRAND
COMPONENTS.
BELOW ARE LISTED A FEW HYDRAULIC FLUIDS THAT HAVE BEEN TESTED AND APPROVED BY THE
SUNDSTRAND
HYDRO-TRANSMISSIDN CORP.
SOURCE
FLUID DESIGNATION
MOBIL OIL CO.
MOBILFLUID #300
AMERICAN OIL CO.
RYCON #21
AMERICAN OIL CO.
LF-5179
VISCOSITY OIL
L-2135
SHELL OIL CO.
DONAX T-7
SHELL OIL CO.
TELLUS T-27
IF IT IS NECESSARY TO ADD OR REFILL IN THE FIELD AND THE ABOVE FLUID CANNOT BE OBTAINED, IT IS
RECOMMENDED THAT AUTOMATIC TRANSMISSION FLUID TYPE A, SUFFIX A BE USED.
THE ABOVE OILS HAVE BEEN TESTED AND APPROVED BY THE SUNDSTRAND HYDRO-TRANSMISSION CORP.,
HOWEVER, A NUMBER OF ACCEPTABLE FLUIDS ARE ON THE MARKET THAT ARE COMPATIBLE. IF FLUIDS
OTHER THAN LISTED ABOVE ARE GOING TO BE USED, THE USER SHOULD TAKE APPROPRIATE STEPS,
INCLUDING TESTING, TO INSURE THE COMPATIBILITY OF THE OIL. CONTACT YOUR LOCAL OIL SUPPLIER.
15-2
