TM 5-3895-369-14
Table 4-3. Troubleshooting Symptom index
Engine Fault Index
Fault
Description
Page
1.
2.
3.
4.
5.
6
7
8.
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
19.
20.
21.
22.
Engine fails to crank or cranks slowly with clutch disengaged ............................................
Engine cranks but will not start - no smoke from exhaust ...................................................
Engine hard to start or will not start - smoke from exhaust ................................................
Engine starts but will not keep running .................................................................................
Engine surges (speed changes) ................................................................................................
Engine idles rough .....................................................................................................................
Engine runs rough or misfires ..................................................................................................
Engine rpm will not reach rated operating speed .................................................................
Engine fails to develop full power ...........................................................................................
Engine exhaust smokes excessively .........................................................................................
Engine operating temperature too high .................................................................................
Engine operating temperature too low ..................................................................................
Engine oil pressure too high ....................................................................................................
Engine oil pressure too low ......................................................................................................
Engine losing oil .........................................................................................................................
Fuel or oil leaking from exhaust manifold .............................................................................
Compression knocks ..................................................................................................................
Excessive fuel consumption ......................................................................................................
Excessive vibration .....................................................................................................................
Unusual engine noise ................................................................................................................
Battery dead and will not hold a charge ..................................................................................
Alternator does not charge batteries ......................................................................................
4-14
4-22
4-26
4-30
4-34
4-36
4-44
4-50
4-54
4-62
4-66
4-74
4-78
4-82
4-88
4-92
4-94
4-96
4-98
4-102
4-110
4-114
Additive System Fault lndex
Fault
Description
Page
23.
Additive pump turns but will not pump additive solution ..................................................
4-118
24.
Additive pump will not operate (will not turn) .....................................................................
4-126
Rotor Tiller Fault Index
Fault
Description
Page
25.
Boom cylinder stutters or will not raise and lower rotor assembly ....................................
4-132
26.
Gate cylinder stutters or will not raise and lower tailboard ................................................
4-136
27.
Spray bar cylinder stutters or will not open and close spray bar .........................................
4-140
Vehicle Fault Index
Fault
Description
Page
28.
29.
Vehicle does not move forward or in reverse correctly
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering is difficult
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
4-144
4-148
4-13
